Arianespace knows cause of Ariane 5 flight deviation but concern remains about range safety

by | Feb 23, 2018 | ESA, Launches, Satellites

The Independent Enquiry Commission chaired by Toni Tolker-Nielsen, ESA Inspector General, has reported the results of its analysis of the Ariane 5 launcher’s trajectory deviation during Flight VA241 flight on 25 January 2018. The faulty launch left SES-14 and Al Yah 3 in a transfer orbit with a dramatically increased inclination of 20.6 degrees, compared with the expected 3 degrees. The apogee and perigee were close to the targeted 45,234 x 249km for the planned super-synchronous orbit.

The analysis found that while the launcher mechanism and the rest of the flight programme operated as planned (including the later “dog leg” manoeuvre by the upper stage to make a small reduction to inclination), an incorrect value set in the system led to the wrong azimuth value being aimed for by the vehicle’s two Inertial reference systems at launch.

The launch azimuth is the angle between north direction and the projection of the initial orbit plane onto the launch location. In effect, it is the compass heading aimed for after launch.

For this VA241 launch a “special” platform azimuth value for the IMU (Inertial Measurement Unit) alignment should have been set at 70 degrees, but was instead mistakenly set to 90 degrees – the more normal setting. The inertial reference system was aligned at the usual and planned 90 degrees azimuth, however a correction of 20 degrees to the target azimuth had to be set so that the rocket thought it was heading to 70 degrees as it flew at 90. This software change was requested because one of the satellites carried, the Al Yah 3 (this is corrected from previously written SES-14), had to be released at a right angle relative to the direction of motion of the rocket (i.e. its velocity vector). This correction was needed to prevent one of the rocket’s gyros going past its null position as this delivery happened.

However, the failure to make the 20 degree azimuth setting change correctly led to the Ariane 5 ECA rocket actually flying with a 20-degree shift southwards to an launch azimuth of 110 degrees in a south easterly direction.

The faulty ground track (shown yellow) was initially faithfully shown on the CNES display of the launch. It is veering further south of its planned South Easterly track (green). Courtesy: CNES

Due to the rarity of such an IMU alignment setting change, the targeting fault was not detected by the standard quality checks carried out during the Ariane 5 preparation. The result was that the launch was sent in a South Easterly direction rather than in the planned Easterly one.

The Independent Enquiry Commission’s work has recommended more robust control of data used in preparation for future missions. Arianespace and ArianeGroup immediately implemented the recommendations and expect Ariane fights to resume in March.

Despite the satisfactory results of the enquiry, local concern remains that the rocket passed close to the town of Kourou with no attempt being made to destroy it for range safety reasons. Meanwhile, the deviation in the trajectory meant that later in the flight telemetry was lost as tracking radars and telemetry receivers at Natal and Ascension Island were pointing in the wrong direction. For most of the flight no-one had any idea where the rocket was until signals were received indicating that the two satellites had reached orbit.

About Seradata

Seradata produce the renowned SpaceTrak Launch & Satellite Database. Trusted by 100 of the world’s leading Space organisations, SpaceTrak is a fully queryable database used for market analysis, failure/risk assessment, spectrum analysis and space situational awareness (SSA).

For more information go to www.seradata.com/spacetrak

Related Articles

Normally reliable Ariane 5 rocket shoots in wrong direction leaving SES-14 and Al Yah 3 in ramped up inclination transfer orbit

The Ariane 5 rocket has had its first actual launch failure after 82 successful flights performed over 15 years. Following an apparently successful lift-off from the Read more

It’s musical chairs for SES as SES-12 and SES-14 swap their Ariane 5 and Falcon 9 launches respectively

In an effort to restore capacity for customers impacted by the recent in-orbit fault on NSS-806 in which 12 of the spacecraft's transponders were Read more

Ageing SES satellite NSS-806 suffers an anomaly affecting 12 transponders

Luxembourg-based global Fixed Service Satellite (FSS) operator SES S.A. revealed alongside its first-half results (released on July 28) that one of its Read more

SES orders three comsats from Airbus DS, Boeing and Orbital ATK – and two will fly from Texas (Corrected)

The global satellite operator, SES, which is headquartered in Luxembourg, has announced the placing of orders for three communications satellites, SES-14, SES-15 and Read more

Arianespace signs up Measat 3d for Ariane 5 launch

Arianespace and the Malaysian regional satellite operator MEASAT Global Berhad (MEASAT) have signed a launch agreement for an Ariane 5 Read more

Ariane 5 rocket puts two safely into orbit: Hellas-Sat 4/SaudiGEOSat-1 & GSAT-31

In its first flight of 2019, an Ariane 5 ECA put two satellites into a geosynchronous transfer orbit (GTO) on Read more

Ariane 5 ECA successfully launches GSAT-11 comsat for India and GEO KOMPSAT-2A weather sat for South Korea

The Ariane 5-ECA roared off its launch pad in Kourou, French Guiana at 2037 GMT on 4 December 2018.  The Read more

Ariane 5 launches for 100th time putting two comsats into orbit

"Arianespace is delighted to announce that Horizons 3e and Azerspace 2/Intelsat 38 have been separated as planned in their targeted Read more

Cookies & Privacy

Click here to read about use of cookies on the website

Categories

Archives