Russian Express AM-6 comsat is launched by Proton but it undershot target orbit (Updated)

by | Oct 22, 2014 | Launches, Russia, Satellites | 0 comments

A Proton M Breeze M launch vehicle launched the Express AM-6 communications spacecraft for the Russian Satellite Communications Company (Komischeskaya Svyaz) at 1509 GMT on 21 October 2014.  The launch took place from the Baikonur Cosmodrome near Tyuratam, Kazakhstan.  However, some hours later reports emerged that the satellite had been put into the wrong orbit by the Breeze M (Briz-M) upper stage which apparently failed to complete its final firing correctly.  

According to US Space Command data, the actual orbit achieved was 37,784 km x 31,307km at an inclination of 0.7 degrees. According to industry sources the actual perigee achieved was some 2,500km less than the planned perigee of previously identical missions of circa 33,800km – while the inclination was also slightly awry at about 0.5 degrees off target.   Nevertheless, the satellite is expected to recover itself into its correct GEO orbit using its own on board Xenon-fuelled electric thrusters.

In fact, the satellite was always supposed to perform the final orbital raising of the mission using its low thrust but highly fuel efficient electric thrusters as the perigee of final orbit were always supposed to be slightly “lower” than for normal geostationary Earth orbit (GEO) missions.  The reason this type of flight plan was employed was that, at 3,358kg, the spacecraft was slightly too heavy to allow the Proton M Breeze M to deliver the spacecraft all the way to GEO. 

The recovery is now expected take some months. After testing, the Express AM-6 spacecraft is likely to reach full operational status in July 2015 – taking about twice as long as originally expected.

TV still of Proton M launch of Express AM-6. Courtesy: Roscosmos

TV still of Proton M launch of Express AM-6. Courtesy: Roscosmos

Express AM-6 was built by ISS Reshetnev using an Express 2000 bus design.  It should be noted that even though spacecraft has been undershot into a lower than planned orbit, the satellite was reported to be carrying an extra two years worth of Xenon fuel beyond its normal 15-year design life as a contingency, and thus should be able to recover itself without any loss of planned lifespan.  As such, no insurance loss is expected.  The insured value of the spacecraft was the Ruble-equivalent of US$140.6 million and is insured locally with Russian insurers with the amount reinsured internationally.

Proton, and especially its Breeze M, upper stage has a very patchy reliability record.  As such, the Express AM-6 launch inaccuracy could mean that Proton launches are delayed until next year while an investigation takes place. 

The Express AM-6 spacecraft is due to operate from the geostationary Earth orbit above 53 degrees East. The satellites communications payload: 44Ku-band, 14 C- band, 12 Ka-band and 2 L-band transponders and associated beams, was built by the Canadian firm of MDA (MacDonald Dettwiler and Associates Ltd).

Comment by David Todd:  There should not be a rush to get Proton flying again.  Its clients and insurers should really press for a delay until the exact cause of this inaccurate launch is found.  Given its recent poor reliability record, the Proton-M launch vehicle probably should not be given the benefit of the doubt.

About Seradata

Seradata produce the renowned SpaceTrak Launch & Satellite Database. Trusted by 100 of the world’s leading Space organisations, SpaceTrak is a fully queryable database used for market analysis, failure/risk assessment, spectrum analysis and space situational awareness (SSA).

For more information go to

Related Articles

Glavkosmos takes over ILS and its marketing of Proton

Glavkosmos, which already has a share in GK Launch Services, the marketing arm for Soyuz rockets, is to have another Read more

ILS gets launch order from satellite life extension specialist Effective Space

International Launch Services (ILS) and UK-headquartered Effective Space has announced that two of its satellite-servicing SPACE DRONE™ spacecraft will be launched Read more

US to bar military use of commercial satellites if flown on Russian rockets after 2023

The US military is now under orders from the US Congress to end the use of any commercial satellites that Read more

Khrunichev to “modularise” Proton rocket to enter medium and small launcher markets

International Launch Services (ILS), the commercial marketing arm of the Russian rocket manufacturer Khrunichev, has announced that the Proton four-stage rocket is Read more

Satellite 2016: Launch providers lay out their likely launch numbers

At the launchers' session at Satellite 2016 in Washington D.C. representatives of the main commercial launch providers laid out their planned launch Read more

Inmarsat books Proton in case SpaceX Falcon Heavy is any further delayed

Inmarsat has taken out an option for a launch on an ILS (International Launch Services) Proton rocket in case its plan Read more

Launcher leaders: Interview with Kirk Pysher, President of ILS

After being hampered by Proton rocket reliability issues, a combination of launch price cuts and the industry’s acknowledgment of the Read more

Russia and China end year with a flurry of launches including the first for Russia’s new Angara A5

The dying days of a year are traditionally the time when Russia and China launch a number of payloads into orbit while Western nations Read more

Cookies & Privacy

Click here to read about use of cookies on the website